Car manual transmission Toyota RAV4 1 (XA10)

General information about the gearbox
The gearbox converts the torque transmitted from the engine in magnitude and direction. This is necessary to ensure optimal speed and cross-country ability of the vehicle, for the most economical operation of the...

Technical data of the gearbox
Technical data of the vehicles are given in the table. 9.1, 9.2, 9.3.

Gearbox repair — general information
The gearbox is a complex unit, and therefore it is recommended to have it repaired at specialized auto service centers. When removing and installing many parts, it is necessary to measure the gaps and adjust them using...

Replacing gearbox control cables
The transmission control cables are not adjustable, so replace them if they become damaged or stretched. Removal Figure 9.1. Transmission control cables on pre-2001 models: 1 – gear shift lever handle; 2 – corrugated...

Removal and installation the gear shift lever
Removal Inside the vehicle, remove the center console. Release the cable retaining clips and disconnect both cables from the gear shift lever. Remove the gear shift lever base mounting bolts and remove the lever from...

Checking and replacing the reverse light switch
Examination Figure 9.2. Location of the reversing light switch on top of the gearbox housing The reversing light switch is located on top of the gearbox housing (figure 9.2). Turn on the ignition and engage reverse...

Replacing the transmission oil cooler
The transmission oil cooler was only installed on all-wheel drive vehicles produced before 2001. Removal Remove the lower engine compartment mud flaps. Remove the front bumper. Unscrew the connecting nuts securing the...

Removal and installation a manual transmission with one driving axle
Removal Turn off the ignition and disconnect the ground wire from the battery. Remove the air filter housing. Remove the expansion tank of the cooling system. With the vehicle standing on its wheels, loosen the nuts...

Removal and installation a manual transmission on all-wheel drive vehicles
Caution! The fuel system is under constant pressure, so relieve the pressure in the fuel system before disconnecting the lines. Caution! The air conditioning system is under high pressure, so do not open the air...

This section is available on: russian, bulgarian, belarusian, ukrainian, serbian, croatian, romanian, polish, slovak, hungarian

Share information:

Similar sections for other Toyota models

➥ Manual gearbox Toyota Corolla E80 (1983-1990)
➥ Mechanical gearbox Toyota Corona T190 (1992-1997)
➥ Car gearbox Toyota Carina T170 (1988-1992)
➥ Mechanical gearbox Toyota Cruiser 70 (1985-1996, diesel)
➥ Mechanical gearbox Toyota 4Runner N120 (1989-1995)
➥ Manual gearbox Toyota Dyna Y50/Y60 (1984-1995)

Link in different formats to this article

TEXTHTMLBB Code

RAV 4 XA20 (2000-2005)